Product Identification
|
EDP Number: |
1130 |
| Product Name: |
TC-303 |
| DOT Hazard: |
CORROSIVE LIQUID |
| DOT ShipName: |
CORROSIVE LIQUID,ACIDIC,INORGANIC,N.O.S. (CONTAINS PHOSPHORIC ACID AND HYDROFLUORIC ACID),8, UN 3264, PG II |
|
Physical Data
| Boil Point |
Freeze Point |
Gravity |
Vapor Pressure |
Vapor Density |
Evap Rate |
% Volatile |
Solubility |
| >212 F |
N/A |
1.09@ 75 F |
N/A |
N/A |
N/A |
~90 |
100 |
|
| Odor and Appearance: |
CLEAR ORANGE LIQUID |
|
Ingedients
| Material Name |
Percentage |
TLV |
Hazard |
CAS Number |
| PHOSPHORIC ACID* |
1 - 10 |
1 MG/M3 |
CORROSIVE |
7664-38-2 |
| HYDROFLUORIC ACID * |
1-5 |
3 PPM |
TOXIC, CORROSIVE |
7664-39-3 |
| WATER |
75 -85 |
N/A |
NONE |
7732-18-5 |
| 2- BUTOXYETHANOL* |
1- 10 |
25 PPM |
SKIN |
111-76-2 |
|
| Note1: |
* THESE CHEMICALS ARE SUBJECT TO THE REPORTING REQUIREMENTS OF SARA III SECTION 313. |
|
Fire and Explosion Hazard Data
| Flash Point |
LEL |
UEL |
| N/A |
N/A |
N/A |
|
| Extinguishing Media |
ANY |
| Unusual Fire & Explosion Hazards |
MAY REACT WITH METALS TO GENERATE HYDROGEN GAS. |
|
| Health Hazard Data |
| Acute Effects |
SEE BELOW |
| Swallowing |
MAY CAUSE IRRITATION, BURNS AND SEVERE DAMAGE TO THE MOUTH, MUCOUS MEMBRANES AND GASTROINTESTINAL SYSTEM AND EVEN DEATH. |
| Inhalation |
MAY CAUSE IRRITATION OR BURNS TO THE RESPIRATORY SYSTEM. |
| Skin Contact |
MAY CAUSE REDNESS, IRRITAION OR EXTREMELY PAINFUL BURNS ON CONTACT WHICH MAY NOT BE IMMEDIATELY VISIBLE. TAKE IMMEDIATE ACTION TO REMOVE PRODUCT. |
| Eye Contact |
MAY CAUSE PERMANENT EYE DAMAGE, REDNESS, TEARING, BLURRED VISION, CORNEAL BURNS, TEARING, DIZZINESS OR HEADACHE. |
| Chronic Effects |
N/A |
| Other Hazards |
N/A |
|
| Emergency First Aid Procedures |
| Swallowing |
GIVE ONE GLASSES OF WATER THEN TWO GLASSES OF MILK. DO NOT INDUCE VOMITING. KEEP PERSON WARM AND QUIET. CONTACT PHYSICIAN IMMEDIATELY. |
| Inhalation |
REMOVE TO FRESH AIR. IF BREATHING PROBLEMS ARE PRESENT CONTACT PHYSICIAN IMMEDIATELY |
| SkinContact |
REMOVE CONTAMINATED CLOTHING. FLUSH WITH WATER FOR 15 MINUTES OR USE STANDARD TREATMENT FOR HYDROFLUORIC ACID, ZEPHARINE HYDROCHLORIDE WASH, IF AVAILABLE. SEEK MEDICAL ATTENTION IMMEDIATELY. CHEMICAL BURNS MAY LINGER FOR HOURS AFTER TREATMENT. |
| Eye Contact |
FLUSH WITH LARGE QUANTITIES OF WATER FOR A MINIMUM OF 15 MINUTES, LIFTING UPPER AND LOWER LIDS OCCASIONALLY. DO NOT PLACE ZEPHARINE HYDROCHLORIDE INTO OR NEAR EYES. SEEK MEDICAL HELP IMMEDIATELY. |
| Primary |
INGESTION |
| Note to Physician |
TREAT AS HYDROFLUORIC ACID CONTACT. |
|
| Reactivity Data |
| Stablility |
STABLE |
| Conditions to Avoid |
HEAT AND CONTAMINATION. |
| Materails to Avoid |
BASES, METALS AND OXIDIZERS. |
| Hazardous Decom Prod |
CARBON MONOXIDE AND OTHER HAZARDOUS CHEMICALS. |
| Hazardous Polymerization |
WILL NOT OCCUR |
| Additional Cond to Avoid |
N/A |
|
| Spill or Leak Procedures |
| Steps if spilled |
WEAR PROTECTIVE CLOTHING. SLOWLY NEUTRALIZE WITH ALKALINE MATERIAL AND MOP UP. |
| Waste Disposal Method |
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. |
|
| Special Protection Information |
| Respiratory Protection |
IF MISTS ARE PRESENT USE ACID NIOSH APPROVED RESPIRATOR |
| Ventilation |
MECHANICAL EXHAUST |
| Impervious Gloves |
IMPERVIOUS |
| Other PPE |
SAFETY GOGLES |
|
| Special Precautions |
| Storage & Handling Precautions |
USE IN WELL-VENTILATED AREAS. |
| Other Precautions |
STORE IN COOL, DRY PLACE |
|
HMIS Ratings
| Health |
3 |
| Flammability |
0 |
| Reactivity |
1 |
| Personal Protective Equipment |
H |
|
| Prepared By: |
JOEL POCHRON
TECHNICAL DIRECTOR
MALCO PRODUCTS, INC.
36l FAIRVIEW AVE P O BOX 892
BARBERTON OHIO 44203
330-753-0361 OR 800-253-2526
These numbers are available days, nights, weekends and holidays. |
|
|
| THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED
REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF. VENDOR ASSUMES NO RESPONSIBILITY
FOR INJURY TO VENDEE OR THIRD PERSONS PROXIMATELY CAUSED BY THE MATERIALS IF REASONABLE SAFETY PROCEDURES ARE NOT ADHERED
TO AS STIPULATED IN THE DATA SHEET. ADDITIONALLY, VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSONS
PROXIMATELY CAUSED BY ABNORMAL USE OF THE MATERIAL, EVEN IF REASONABLE SAFETY PROCEDURES ARE FOLLOWED. FURTHERMORE, VENDEE
ASSUMES THE RISK IN HIS USE OF THE MATERIAL. |
|
to Automotive MSDS Listings