Product Identification
|
EDP Number: |
1160m |
| Product Name: |
SEMI-GLOSS BLACK PAINT - AEROSOL PAINT |
| DOT Hazard: |
CONSUMER COMMODITY |
| DOT ShipName: |
ORM-D DOMESTIC U.N.1950 INTERNATIONAL |
|
Physical Data
| Boil Point |
Freeze Point |
Gravity |
Vapor Pressure |
Vapor Density |
Evap Rate |
% Volatile |
Solubility |
| 133 F |
N/A |
<1 |
N/A |
>1 |
N/A |
85-95 |
SLIGHT |
|
| Odor and Appearance: |
BLACK LIQUID WITH SOLVENT ODOR |
|
Ingedients
| Material Name |
Percentage |
TLV |
Hazard |
CAS Number |
| ACETONE* |
40 - 45 |
750 PPM |
FLAMMABLE |
67-64-1 |
| ALIPHATIC HYDROCARBON |
5 - 10 |
NE |
FLAMMABLE |
64742-89-8 |
| AROMATIC HYDROCARBON |
0 -5 |
NE |
FLAMMABLE |
64742-95-6 |
| TOLUENE* |
5 - 10 |
100 PPM |
FLAMMABLE/TOXIC |
108-88-3 |
| XYLENE* |
0 - 5 |
100 PPM |
FLAMMABLE |
1330-20-7 |
| PROPANE/ISOBUTANE |
30 |
1000 PPM |
FLAMMABLE/ASPHYXIANT |
68476-86-8 |
|
| Note1: |
* THESE CHEMICALS ARE SUBJECT TO THE REPORTING REQUIREMENTS OF SARA TITLE III. |
|
Fire and Explosion Hazard Data
| Flash Point |
LEL |
UEL |
| 0 F |
1.0 |
N/A |
|
| Extinguishing Media |
WATER, FOG, CO2, OR DRY CHEMICAL |
| Unusual Fire & Explosion Hazards |
AT ELEVATED TEMPERATURES - ABOVE 120 F - CONTAINERS MAY RUPTURE,VENT OR BURST. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL DISTANCES TO IGNITION SOURCES. |
|
| Health Hazard Data |
| Acute Effects |
SEE BELOW |
| Swallowing |
MAY CAUSE GASTROINTESTINAL IRRITATION, NAUSEA OR DIARRHEA |
| Inhalation |
EXCESSIVE INHALATION CAN CAUSE NASAL AND RESPIRATORY IRRITATION, FATIGUE, NAUSEA, UNCONSCIOUSNESS AND EVEN DEATH. |
| Skin Contact |
MAY CAUSE IRRITATION OR REDNESS. |
| Eye Contact |
MAY CAUSE IRRITATION, REDNESS, TEARING OR BLURRED VISION. |
| Chronic Effects |
N/A |
| Other Hazards |
N/A |
|
| Emergency First Aid Procedures |
| Swallowing |
DO NOT INDUCE VOMITING.ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL. SEEK MEDICAL HELP IMMEDIATELY. |
| Inhalation |
MOVE TO FRESH AIR SOURCE. IF BREATHING PROBLEMS ARE PRESENT SEEK MEDICAL HELP IMMEDIATELY |
| SkinContact |
WASH WITH SOAP AND WATER. |
| Eye Contact |
FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING OPEN THE EYE LID. SEEK MEDICAL HELP IMMEDIATELY |
| Primary |
INHALATION |
| Note to Physician |
N/A |
|
| Reactivity Data |
| Stablility |
YES |
| Conditions to Avoid |
DO NOT STORE AT ELEVATED TEMPERATURES. |
| Materails to Avoid |
STRONG OXIDIZERS AND STRONG ACIDS |
| Hazardous Decom Prod |
CARBON MONOXIDE AND OTHER HAZARDOUS CHEMICALS |
| Hazardous Polymerization |
NO |
| Additional Cond to Avoid |
N/A |
|
| Spill or Leak Procedures |
| Steps if spilled |
ELIMINATE ALL IGNITION SOURCES. ABSORB LIQUID ON PAPER, VERMICUTILE OR OTHER FLOOR ABSORBANT MATERIALS AND TRANSFER TO A CLOSED CONTAINER. |
| Waste Disposal Method |
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS |
|
| Special Protection Information |
| Respiratory Protection |
AVOID BREATHING VAPORS. IN CONFINED SPACES US AN NIOSH APPORVED RESIPATOR |
| Ventilation |
MECHANICAL EXHAUST TO REMAIN UNDER THE TLV |
| Impervious Gloves |
YES |
| Other PPE |
SAFETY GOGLES |
|
| Special Precautions |
| Storage & Handling Precautions |
N/A |
| Other Precautions |
N/A |
|
HMIS Ratings
| Health |
1 |
| Flammability |
4 |
| Reactivity |
0 |
| Personal Protective Equipment |
E |
|
| Prepared By: |
JOEL POCHRON
TECHNICAL DIRECTOR
MALCO PRODUCTS, INC.
36l FAIRVIEW AVE P O BOX 892
BARBERTON OHIO 44203
330-753-0361 OR 800-253-2526
These numbers are available days, nights, weekends and holidays. |
|
|
| THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED
REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF. VENDOR ASSUMES NO RESPONSIBILITY
FOR INJURY TO VENDEE OR THIRD PERSONS PROXIMATELY CAUSED BY THE MATERIALS IF REASONABLE SAFETY PROCEDURES ARE NOT ADHERED
TO AS STIPULATED IN THE DATA SHEET. ADDITIONALLY, VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSONS
PROXIMATELY CAUSED BY ABNORMAL USE OF THE MATERIAL, EVEN IF REASONABLE SAFETY PROCEDURES ARE FOLLOWED. FURTHERMORE, VENDEE
ASSUMES THE RISK IN HIS USE OF THE MATERIAL. |
|
to Automotive MSDS Listings