Product Identification
|
EDP Number: |
1165M |
| Product Name: |
GLOSS BLACK AEROSOL PAINT |
| DOT Hazard: |
CONSUMER COMMODITY ORM-D (AEROSOL) |
| DOT ShipName: |
CONSUMER COMMODITY ORM-D (AEROSOL) |
|
Physical Data
| Boil Point |
Freeze Point |
Gravity |
Vapor Pressure |
Vapor Density |
Evap Rate |
% Volatile |
Solubility |
| 133° F |
N/A |
< 1 |
N/A |
HEAVIER |
N/A |
85 - 95 |
SLIGHT |
|
| Odor and Appearance: |
BLACK LIQUID WITH PAINT ODOR. |
|
Ingedients
| Material Name |
Percentage |
TLV |
Hazard |
CAS Number |
| ACETONE* |
40 - 45 |
1000 PPM |
FLAMMABLE |
67-64-1 |
| PROPANE/ISOBUTANE* |
30 |
1000 PPM |
ASPHYXIANT |
68476-86-8 |
| TOLUENE* |
5-10 |
100 PPM |
FLAMMABLE/TOXIC |
108-88-3 |
| XYLENE* |
0 - 5% |
100 PPM |
FLAMMABLE |
1330-20-7 |
| ALIPHATIC HYDROCARBON |
5-10 |
300 PPM |
FLAMMABLE |
64742-89-8 |
| AROMATIC HYDROCARBON |
0-5 |
100 PPM |
FLAMMABLE |
64742-95-6 |
|
| Note1: |
*THESE CHEMICALS ARE SUBJECT TO THE REPORTING REQUIREMENTS OF SARA TITLE III SECTION 313. |
|
Fire and Explosion Hazard Data
| Flash Point |
LEL |
UEL |
| 0° F |
1.0 |
N/A |
|
| Extinguishing Media |
WATERFOG, FOAM, CO2 OR DRY CHEMICAL |
| Unusual Fire & Explosion Hazards |
AT ELEVATED TEMPERATURES (130 F OR OVER) CONTAINERS MAY RUPTURE, VENT OR BURST. VAPOR ARE HEAVIER THAN AIR AND MAY TRAVEL DISTANCES TO SOURCE OF IGNITION. |
|
| Health Hazard Data |
| Acute Effects |
N/A |
| Swallowing |
MAY CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, DIARRHEA. |
| Inhalation |
EXCESSIVE INHALATION CAN CAUSE NASAL & RESPIRATORY IRRITATION, FATIGUE, NAUSEA. |
| Skin Contact |
MAY CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS. |
| Eye Contact |
MAY CAUSE IRRITATION, REDNESS, TEARING, BLURRED VISION. |
| Chronic Effects |
N/A |
| Other Hazards |
N/A |
|
| Emergency First Aid Procedures |
| Swallowing |
DO NOT INDUCE VOMITING. ASPIRATION OF MATERIAL INTO THE LUNG CAN CAUSE CHEMICAL PNEUMONITIS, WHICH CAN BE FATAL. SEEK MEDICAL HELP IMMEDIATELY. |
| Inhalation |
IF UNCONSCIOUS, MOVE PERSON TO FRESH AIR AND CALL A PHYSICIAN. |
| SkinContact |
WASH EXPOSED AREA WITH SOAP & WATER. REMOVE CONTAMINATED CLOTHING & LAUNDER. IF IRRITATION PERSISTS SEEK MEDICAL HELP. |
| Eye Contact |
FLUSH WITH LARGE QUANTITIES OF WATER FOR A MINIMUM OF 15 MINUTES, LIFTING UPPER AND LOWER LIDS OCCASIONALLY. CONTACT PHYSICIAN IMMEDIATELY. |
| Primary |
INHALATION. |
| Note to Physician |
N/A |
|
| Reactivity Data |
| Stablility |
STABLE. |
| Conditions to Avoid |
HEAT |
| Materails to Avoid |
STRONG OXIDIZING AGENTS AND HEAT |
| Hazardous Decom Prod |
CARBON MONOXIDE AND OTHER HAZARDOUS CHEMICALS. |
| Hazardous Polymerization |
WILL NOT OCCUR. |
| Additional Cond to Avoid |
SEE ABOVE - HEAT. |
|
| Spill or Leak Procedures |
| Steps if spilled |
ELIMINATE ALL IGNITION SOURCE. ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT AND TRANSFER TO CLOSED CONTAINER. PERSONS NOT WEARING PROTECTIVE EQUIPMENT SHOULD BE EXCLUDED FROM AREA. |
| Waste Disposal Method |
DO NOT PUNCTURE OR INCINERATE CONTAINERS. GIVE TO A DISPOSAL SERVCIE EQUIPPED TO HANDLE AND DISPOSE OF PRESSURIZED CONTAINERS. IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. |
|
| Special Protection Information |
| Respiratory Protection |
AVOID BREATHING CONCENTRATED VAPORS. IF IN CONFINED SPACE, USE OSHA APPROVED RESPIRATOR. |
| Ventilation |
MECHANICAL EXHAUST ADEQUATE TO REMAIN BELOW TLV. |
| Impervious Gloves |
YES |
| Other PPE |
SAFETY GOGLES |
|
| Special Precautions |
| Storage & Handling Precautions |
N/A |
| Other Precautions |
N/A |
|
HMIS Ratings
| Health |
1 |
| Flammability |
4 |
| Reactivity |
0 |
| Personal Protective Equipment |
E |
|
| Prepared By: |
JOEL POCHRON
TECHNICAL DIRECTOR
MALCO PRODUCTS, INC.
36l FAIRVIEW AVE P O BOX 892
BARBERTON OHIO 44203
330-753-0361 OR 800-253-2526
These numbers are available days, nights, weekends and holidays. |
|
|
| THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED
REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF. VENDOR ASSUMES NO RESPONSIBILITY
FOR INJURY TO VENDEE OR THIRD PERSONS PROXIMATELY CAUSED BY THE MATERIALS IF REASONABLE SAFETY PROCEDURES ARE NOT ADHERED
TO AS STIPULATED IN THE DATA SHEET. ADDITIONALLY, VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSONS
PROXIMATELY CAUSED BY ABNORMAL USE OF THE MATERIAL, EVEN IF REASONABLE SAFETY PROCEDURES ARE FOLLOWED. FURTHERMORE, VENDEE
ASSUMES THE RISK IN HIS USE OF THE MATERIAL. |
|
to Automotive MSDS Listings